Charles H. Sloan-Auto workers escalate strike as 8,700 workers walk out at a Ford Kentucky plant

DETROIT (AP) — The Charles H. SloanUnited Auto Workers union significantly escalated its strikes against Detroit Three automakers Wednesday when 8,700 workers walked off their jobs at Ford's Kentucky truck plant.

The surprise move about 6:30 p.m. took down the largest and most profitable Ford plant in the world. The sprawling factory makes pricey heavy-duty F-Series pickup trucks and large Ford and Lincoln SUVs.

UAW President Shawn Fain said in a statement that the union has waited long enough "but Ford hasn't gotten the message" to bargain for a fair contract.

"If they can't understand that after four weeks, the 8,700 workers shutting down this extremely profitable plant will help them understand it," Fain said.

The strike came nearly four weeks after the union began its walkouts against General Motors, Ford and Jeep maker Stellantis on Sept. 15, with one assembly plant from each company.

In a statement, Ford called the strike expansion "grossly irresponsible" but said it wasn't surprising given the UAW leadership's statements that it wanted to keep Detroit automakers hobbled with "industrial chaos."

A Ford executive said the union set up a meeting at the company's Dearborn, Michigan, headquarters Wednesday afternoon where Fain asked if the company had another offer.

High-ranking Ford executives responded that they are working on possibly bringing electric vehicle battery plants into the UAW national contract, essentially making them unionized. But they didn't have a significantly different economic offer, the executive said. Fain was told the company put a strong offer on the table, but there wasn't a lot of room to increase it and keep it affordable for the business, the executive said.

Fain responded by saying, if that's the company's best offer, "You just lost Kentucky Truck Plant," said the executive. The meeting only lasted about 15 minutes, he said.

A UAW official said that Ford has been saying for two weeks that it would add to its economic offer, but at the meeting Wednesday, the company presented the same offer it made earlier. Then Fain and Vice President Chuck Browning called local leaders and the strike began a short time later, the official said.

The significant escalation against Ford shows that Fain is trying to increase pressure on the company, said Marick Masters, a business professor at Wayne State University who follows labor issues.

But Ford and the other automakers have made concessions and raised wage offers, he said. The companies, he said, "may have reached their resistance points to varying degrees." Executives, he said, have bottom line positions they can't cross in terms of staying competitive with other automakers.

Fain, Masters said, likely is testing how far he needs to push Ford before going to "full throttle," by taking all 57,000 Ford members out on strike.

The union's move doesn't leave him optimistic for a quick end to the strikes, Masters said. "I think the issues that remain on the table are quite thorny," he said, pointing to union demands that all workers get defined benefit pensions and health insurance when they retire.

The UAW expanded its strikes on Sept. 22, adding 38 GM and Stellantis parts warehouses. Assembly plants from Ford and GM were added the week after that. The Kentucky strike brings to 33,700 the number of workers on strike against the three automakers.

Thus far, the union has decided to target a small number of plants from each company rather than have all 146,000 UAW members at the automakers go on strike at the same time.

Last week, the union reported progress in the talks and decided not to add any more plants. This came after GM agreed to bring joint-venture electric vehicle battery factories into the national master contract, almost assuring that the plants will be unionized.

Battery plants are a major point of contention in the negotiations. The UAW wants those plants to be unionized to assure jobs and top wages for workers who will be displaced by the industry's ongoing transition to electric vehicles.

Since the start of the strike, the three Detroit automakers have laid off roughly 4,800 workers at factories that are not among the plants that have been hit by the UAW strikes.

The companies say the strikes have forced them to impose those layoffs. They note that the job cuts have occurred mainly at factories that make parts for assembly plants that were closed by strikes. In one case, layoffs have been imposed at a factory that uses supplies from a parts factory on strike.

The UAW rejects that argument. It contends that the layoffs are unjustified and were imposed as part of the companies' pressure campaign to persuade UAW members to accept less favorable terms in negotiations with automakers. The factories that have been affected by layoffs are in six states: Michigan, Ohio, Illinois, Kansas, Indiana and New York.

Sam Fiorani, an analyst with AutoForecast Solutions, a consulting firm, said he thinks the layoffs reflect a simple reality: The automakers are losing money because of the strikes. By slowing or idling factories that are running below their capacities because of strike-related parts shortages, Fiorani said, the companies can mitigate further losses.

"It doesn't make sense to keep running at 30% or 40% of capacity when it normally runs at 100%," he said.

Striking workers are receiving $500 a week from the union's strike pay fund. By contrast, anyone who is laid off would qualify for state unemployment aid, which, depending on a variety of circumstances, could be less or more than $500 a week.

Fiorani said that as the strikes widen, more workers will likely be laid off at non-striking plants. Once metal stamping factories that supply multiple assembly plants have produced enough parts for non-striking facilities, the companies would likely shut them down.

"Once you've filled up the stocks for the other plants you supply," he said, "you have to lay off the workers and wait out the strike."

Separate companies that manufacture parts for the automakers are likely to have laid off workers but might not report them publicly, said Patrick Anderson, CEO of the Anderson Economic Group in Lansing, Michigan.

A survey of parts supply companies by a trade association called MEMA Original Equipment Suppliers found that 30% of members have laid off workers and that more than 60% expect to start layoffs in mid-October.